Maintained by Seed's editors, web editors, and the other people who make Seed tick, Page 3.14 points you in the direction of some of ScienceBlogs' finest offerings, plus the tastiest tidbits of science news and opinion from around the web.
Researchers at Purdue University have created a portable refinery that converts food, paper and plastic trash into electricity. The prototype biorefinery generates approximately 90 percent more energy than it consumes.
Its efficiency owes to a series of steps:
1. Separate organic food material from residual trash, such as paper, plastic, Styrofoam and cardboard.
2. Ferment food waste into ethanol with industrial yeast.
3. Transfer non-food waste to a gasifier, where it is heated under low-oxygen conditions until it breaks down into low-grade propane gas and methane.
4. Combust gas (from non-food waste) and ethanol (from food waste) in a modified diesel engine that powers a generator to produce electricity.
Much of the process is carbon-neutral, according to Nathan Mosier, a Purdue professor of agricultural and biological engineering involved in the project. The ash output amounts to a 30 to 1 waste volume reduction.
And finally, most importantly (to the U.S. Army that is now supporting this research)--the whole apparatus could fit in a minivan.
Hat-tip, Slashdot.
Comments
Huh? "90% more energy than it consumes" ???? Seems to violate a few laws of physics. I think they mean 90% of the energy it consumes.
Posted by: Tom S | February 8, 2007 12:03 PM
The quote from the press release is:
To clarify, I don't think they mean that the refinery produces 90% more energy than the chemical energy stored in the garbage. If so, then you'd be right.
What I think they mean, and correct me if necessary, is that the refinery produces 90% more energy than the electricity it takes to run the thing.
Posted by: Sarah Dasher | February 8, 2007 12:11 PM
They are not particularly concerned with whether it would be economic in your backyard. Rather if a military Forward Operating Base might be able to reduce the amount of supplies (like fuel) it needs to operate.
The high cost and danger of shipping supplies *might* justify the cost. These folks are also very interested in modules that contain photovoltaics and/or wind generators for the same reason.
It seems that at least a little bit of the money for war is going towards renewables!
Posted by: bigTom | February 8, 2007 4:01 PM